1. California Lemon Law
2. Recalls
3. VOLVO
4. VNL

Recalls For 2017 VOLVO VNL

CALL TODAY 888-395-3666 to find out if you are eligible for a California Lemon Law refund, or complete the free case review form above, if you are having problems with your 2017 VOLVO VNL.

Recall #1 Issued: 2016 02 17 - Camp #20160217

This 2017 VOLVO VNL recall affects the STEERING Manufactured by Volvo Trucks North America from 2015-05-11 through 2016-04-18

Description Of Defect

Volvo Trucks North America (Volvo) is recalling certain model year 2016-2017 VNL, VNX, and VNM trucks manufactured from May 11, 2015, through April 18, 2016. The trucks may have been manufactured without a roll pin on the steering shafts. If the roll pin is missing, the lower steering shaft may disconnect from the junction block. Also, the bolt connecting the upper steering shaft to the lower steering shaft may not have been properly tightened. Either condition can lead to separation of the steering shaft.

Conseqence Of Defect

Separation of the steering shaft will result in complete loss of steering which may lead to a vehicle crash.

Corrective Action

Volvo is strongly recommending that the affected vehicles not be driven until the interim remedy is applied. An interim notice was sent to Volvo owners on March 16, 2016, and an interim repair is available now. A second notice was mailed on May 13, 2016. The final remedy is now available. Both remedies are free of charge. Owners may contact Volvo customer service at 1-877-800-4945 opt #1. Volvo's recall numbers for this campaign are RVXX1602 and RVXX1603. This recall supersedes safety recall 15V-786.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall #2 Issued: 2016 06 01 - Camp #20160601

This 2017 VOLVO VNL recall affects the ENGINE AND ENGINE COOLING:ENGINE:DIESEL Manufactured by Volvo Trucks North America from 2016-03-15 through 2016-04-20

Description Of Defect

Volvo Trucks North America (Trucks) is recalling certain model year 2017 VNL trucks manufactured March 15, 2016, to April 20, 2016, equipped with a Cummins ISX12 or ISX15 engine using certain engine control modules (ECM). These ECM's may experience an internal electrical short that can cause a fuse to blow, resulting in an unexpected engine stall without the ability to restart the engine.

Conseqence Of Defect

An engine stall can increase the risk of a crash.

Corrective Action

Cummins will notify owners, and Cummins dealers will replace the existing ECM with a new ECM, free of charge. The recall began on July 11, 2016. Owners may contact Cummins customer service at 1-800-343-7357 or Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1604.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall #3 Issued: 2016 12 22 - Camp #20161222

This 2017 VOLVO VNL recall affects the SERVICE BRAKES, AIR Manufactured by Volvo Trucks North America from 2012-04-11 through 2016-09-27

Description Of Defect

Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.

Conseqence Of Defect

If the brake system becomes contaminated, braking performance could be affected, increasing the risk of a crash.

Corrective Action

Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1608.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall #4 Issued: 2016 12 22 - Camp #20161222

This 2017 VOLVO VNL recall affects the SUSPENSION:FRONT:HUB Manufactured by Volvo Trucks North America from 2016-02-19 through 2016-06-21

Description Of Defect

Volvo Trucks North America (Volvo) is recalling certain 2017 Volvo VHD, VNL, and VNM trucks manufactured February 19, 2016, to June 21, 2016. The affected vehicles were built with front wheel hubs that cannot support the gross axle weight rating of the front axle.

Conseqence Of Defect

Overloaded front wheel hubs can result in premature failure of the hubs, bearings, and the related components, which can cause the front hub assembly to separate from the front axle. Because of this, the driver may lose control of the vehicle or parts may be dropped on the road, increasing the risk of a crash.

Corrective Action

Volvo will notify owners, and dealers will replace the hub assemblies, free of charge. The recall began on February 16, 2017. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1607.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall #5 Issued: 2018 09 25 - Camp #20180925

This 2017 VOLVO VNL recall affects the ENGINE AND ENGINE COOLING:ENGINE:DIESEL Manufactured by Volvo Trucks North America from 2015-12-04 through 2018-07-26

Description Of Defect

Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.

Conseqence Of Defect

If the fuel line bursts, fuel may leak onto the road resulting in a roadway hazard for other motorists. The engine may also stall without warning, resulting in the vehicle's inability to restart, increasing the risk of a crash.

Corrective Action

Cummins will notify owners, and dealers will replace the single screen filter banjo bolt will be replaced with a dual screen filter banjo bolt, free of charge. The recall began November 21, 2018. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1802.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.