Recalls For 2009 VOLKSWAGEN ROUTAN

CALL TODAY 888-395-3666 to find out if you are eligible for a California Lemon Law refund, or complete the free case review form above, if you are having problems with your 2009 VOLKSWAGEN ROUTAN.

Recall #1 Issued: 2009 07 01 - Camp #20090701

This 2009 VOLKSWAGEN ROUTAN recall affects the EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Manufactured by VOLKSWAGEN OF AMERICA, INC from 2008-06-26 through 2009-04-24

Description Of Defect

VOLKSWAGEN IS RECALLING 18,500 MY 2009 ROUTAN VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE OWNER'S MANUAL WAS PRINTED WITHOUT THE FMVSS NO. 208 REQUIRED INFORMATION EXPLAINING THAT NO OBJECTS SHOULD BE PLACED OVER THE OR NEAR THE AIR BAG ON THE INSTRUMENT PANEL.

Conseqence Of Defect

ANY SUCH OBJECTS COULD CAUSE INJURY TO THE VEHICLE'S OCCUPANTS IN THE EVENT OF A CRASH SEVERE ENOUGH TO CAUSE THE AIR BAG TO INFLATE.

Corrective Action

DEALERS WILL SEND AN OWNER'S MANUAL INSERT CONTAINING THE REQUIRED AIR BAG INFORMATION FOR OWNER INSTALLATION OR DEALERS WILL INSTALL IN THE EVENT THE OWNER PREFERS ASSISTANCE FROM THE DEALER. THE RECALL BEGAN ON JULY 31, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Additional Notes

VOLKSWAGEN RECALL NO. S6.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Recall #2 Issued: 2010 06 10 - Camp #20100610

This 2009 VOLKSWAGEN ROUTAN recall affects the ELECTRICAL SYSTEM:WIRING Manufactured by VOLKSWAGEN OF AMERICA, INC from 2008-06-01 through 2009-07-30

Description Of Defect

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 ROUTAN VEHICLES MANUFACTURED FROM JUNE 2008 THROUGH JULY 2009. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION. CONTACT WITH A 12V POWER FEED CIRCUIT WITHIN THE HARNESS MAY CAUSE A HIGH RESISTIVE SHORT CIRCUIT WITHIN THE LATCH MECHANISM LOCATED INSIDE OF THE SLIDING DOOR.

Conseqence Of Defect

THIS COULD RESULT IN AN OVERHEATED LATCH AND A FIRE WITHIN THE REAR SLIDING DOOR COULD OCCUR.

Corrective Action

VOLKSWAGEN WILL INSPECT THE SLIDING DOOR WIRE TRACK WIRE ASSEMBLY AND THE SLIDING DOOR POWER DRIVE UNIT WIRE ASSEMBLY FOR DAMAGE, REPAIR/REPLACE AS NECESSARY, TIE STRAP THE TWO HARNESSES TOGETHER AND ROUTE THE HARNESSES UNDER THE SLIDING DOOR WEATHER STRIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 15, 2010. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Additional Notes

VOLKSWAGEN SAFETY RECALL NO. 97S8/T7.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Recall #3 Issued: 2014 02 11 - Camp #20140211

This 2009 VOLKSWAGEN ROUTAN recall affects the SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY Manufactured by Freedom Motors, Inc.

Description Of Defect

Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.

Conseqence Of Defect

Failure of the rear axle may increase the risk of a crash.

Corrective Action

Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall #4 Issued: 2014 07 01 - Camp #20140701

This 2009 VOLKSWAGEN ROUTAN recall affects the ELECTRICAL SYSTEM:IGNITION Manufactured by Volkswagen of America, Inc.

Description Of Defect

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Conseqence Of Defect

If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.

Corrective Action

Volkswagen will notify owners, and dealers will modify the ignition switch, free of charge. Owners may contact Volkswagen customer service at 1- 800-822-8987. An interim notice was mailed to owners on August 29, 2014. Volkswagen's number for this recall is 28G1/U8. Note: This campaign is an expansion of NHTSA Recall No. 11V-151.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall #5 Issued: 2015 04 01 - Camp #20150401

This 2009 VOLKSWAGEN ROUTAN recall affects the ELECTRICAL SYSTEM:IGNITION:SWITCH Manufactured by Volkswagen Group of America, Inc. from 2008-06-25 through 2009-07-08

Description Of Defect

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles manufactured June 25, 2008, to July 8, 2009, and 2010 Routan vehicles manufactured October 1, 2009, to August 11, 2010. This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Conseqence Of Defect

If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including, but not limited to, air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.

Corrective Action

Volkswagen will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on June 23, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 28H1. Note: This recall supersedes recalls 11V151 and 14V396. Vehicles that previously received an ignition switch trim ring as a recall remedy must have their vehicles remedied again under this campaign. Vehicles that have already received a new ignition switch are not covered by this campaign.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall #6 Issued: 2016 02 11 - Camp #20160211

This 2009 VOLKSWAGEN ROUTAN recall affects the AIR BAGS:FRONTAL Manufactured by Volkswagen Group of America, Inc. from 2008-02-07 through 2008-08-28

Description Of Defect

Volkswagen Group of America, Inc. (VW) is recalling certain model year 2009 Volkswagen Routan vehicles manufactured February 7, 2008, to August 28, 2008. In the affected vehicles, the air bag control units may corrode and fail.

Conseqence Of Defect

If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.

Corrective Action

VW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began April 2016. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall #7 Issued: 2016 02 11 - Camp #20160211

This 2009 VOLKSWAGEN ROUTAN recall affects the AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE Manufactured by Volkswagen Group of America, Inc. from 2008-02-07 through 2008-08-28

Description Of Defect

Volkswagen Group of America, Inc. (VW) is recalling certain model year 2009 Volkswagen Routan vehicles manufactured February 7, 2008, to August 28, 2008. In the affected vehicles, the air bag control units may corrode and fail.

Conseqence Of Defect

If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.

Corrective Action

VW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began April 2016. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.