Recalls For 2018 CHEVROLET SILVERADO 3500

CALL TODAY 888-395-3666 to find out if you are eligible for a California Lemon Law refund, or complete the free case review form above, if you are having problems with your 2018 CHEVROLET SILVERADO 3500.

Recall #1 Issued: 2017 09 14 - Camp #20170914

This 2018 CHEVROLET SILVERADO 3500 recall affects the SEAT BELTS:FRONT:RETRACTOR Manufactured by General Motors LLC

Description Of Defect

General Motors (GM) is recalling certain 2017-2018 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 trucks. The front seat belt retractor assemblies were built with the incorrect torsion bar. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."

Conseqence Of Defect

The seat belt retractors may not perform as intended during a crash, increasing the risk of injury.

Corrective Action

GM will notify owners, and dealers will replace both front seat belt retractor assemblies, free of charge. The recall began March 24, 2021. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's numbers for this recall are 17368, 17375, and 17376.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall #2 Issued: 2019 02 07 - Camp #20190207

This 2018 CHEVROLET SILVERADO 3500 recall affects the FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY Manufactured by General Motors LLC from 2017-09-26 through 2017-10-06

Description Of Defect

General Motors, LLC (GM) is recalling certain 2016-2018 GMC Sierra 3500 and Chevrolet Silverado 3500 trucks equipped with gasoline engines and dual fuel tanks. The fuel-level sensor in the front tank may stick in a low-level position, allowing the rear tank to overfill the front tank.

Conseqence Of Defect

If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.

Corrective Action

GM has notified owners, and dealers will replace the rear-tank fuel-pump module, inspect the front tank and, if necessary, replace the front tank, free of charge. The recall began July 30, 2019. GM's number for this recall is N182204190.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov

Recall #3 Issued: 2019 04 25 - Camp #20190425

This 2018 CHEVROLET SILVERADO 3500 recall affects the ENGINE Manufactured by General Motors LLC

Description Of Defect

General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.

Conseqence Of Defect

A short-circuit may damage the engine components and increase the risk of fire.

Corrective Action

GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall #4 Issued: 2021 07 01 - Camp #20210701

This 2018 CHEVROLET SILVERADO 3500 recall affects the EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER Manufactured by General Motors, LLC

Description Of Defect

General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.

Conseqence Of Defect

An electrical short-circuit can increase the risk of a fire.

Corrective Action

Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. Interim owner notifications were mailed on August 13, 2021. Owner notification letters are expected to be mailed on April 4, 2022. Customers may call GMC customer service at 1-800-462-8782. GM's number for this recall is 212329840.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Recall #5 Issued: 2023 02 02 - Camp #20230202

This 2018 CHEVROLET SILVERADO 3500 recall affects the FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY Manufactured by General Motors, LLC

Description Of Defect

General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.

Conseqence Of Defect

An engine stall increases the risk of a crash.

Corrective Action

Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Recall #6 Issued: 2024 10 10 - Camp #20241010

This 2018 CHEVROLET SILVERADO 3500 recall affects the AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR Manufactured by General Motors, LLC

Description Of Defect

General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2018-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 Crew Cab trucks. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Conseqence Of Defect

A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Corrective Action

Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.

Additional Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.