Tag Archives: Stellantis

Jeep Gladiator And Wrangler Instrument Panel Failure

Posted on by

Jeep Instrument Panel FailureFiat Chrysler Automobiles (FCA) US have decided that there is a safety related problem affecting certain 2020-2024 Jeep Gladiator and 2018-2024 Jeep Wrangler vehicles. The recall was prompted by an issue that could cause the instrument panel cluster (IPC) to fail, leading to a blank display. This defect may occur due to an internal short circuit, which could compromise the instrument panel’s functionality and cause the vehicle to fall out of compliance with Federal Motor Vehicle Safety Standard (FMVSS) No. 101, which governs controls and displays in vehicles.

The problem was first identified by FCA’s Technical Safety and Regulatory Compliance (TSRC) organization, which had received reports of blank IPCs in affected models. Following this, the TSRC conducted a detailed analysis, including reviewing patterns of IPC failures and performing warranty part return inspections. After collaborating with suppliers and conducting rigorous testing, it was determined that the IPCs in certain vehicles might experience an internal short circuit, causing the display to go blank unexpectedly.

A non-functional instrument panel cluster is a serious concern, as it can result in drivers losing access to critical vehicle information such as speed, fuel levels, and warning indicators. This increases the risk of accidents and reduces the driver’s ability to make informed decisions while operating the vehicle.

On August 30, 2024, FCA US decided, through its Vehicle Regulations Committee, to issue a safety recall for the affected vehicles. The recall applies to Jeep Wrangler models manufactured between 2018 and 2024, as well as Jeep Gladiator models produced from 2020 to 2024. To address the issue, FCA will replace the faulty instrument panel cluster in affected vehicles.

The recall is identified as FCA campaign number 30B, and the corresponding National Highway Traffic Safety Administration (NHTSA) campaign number is 24V-652.

Rear View Camera Issue Prompts FCA Recall of Over One Million Vehicles

Posted on by

blank-dashboard-displayChrysler (FCA US, LLC) is taking steps to address an issue affecting the rear view cameras in over a million of its vehicles. On October 23, 2023, the FCA Technical Safety and Regulatory Compliance (TSRC) organization was alerted to a potential problem where rear view cameras were not displaying images in certain Dodge, Chrysler, Jeep, and Ram models. This issue potentially violates the Federal Motor Vehicle Safety Standards (FMVSS) for rear visibility.

An investigation revealed that a software glitch in the radio system of these vehicles could cause the rear view camera to fail to display the required image when the vehicle is put into reverse. This noncompliance with FMVSS No. 111, which mandates that rear visibility systems must default to showing the rear view image and adhere to specific field of view and image size requirements at the start of each backing event, regardless of any prior modifications made by the driver.

The issue, affecting 1,033,433 units, was identified during a thorough investigation. By June 2024, FCA US’s Vehicle Regulations Committee determined that a voluntary safety recall was necessary to rectify the problem.

The vehicles affected include:

2021-2023 Chrysler Pacifica
2021-2022 Dodge Durango
2022-2023 Jeep Compass
2021-2023 Jeep Grand Cherokee
2022-2023 Jeep Grand Wagoneer
2022-2023 Jeep Wagoneer
2022 RAM 1500
2022 RAM 2500
2022 RAM 3500
2022-2023 RAM Promaster

NOTE: Owners of these vehicles will notice that the rear view image does not appear when the vehicle is placed into reverse.

To resolve this issue, dealers will update the radio software in the affected vehicles. Owner notification letters are scheduled to be mailed out by August 2, 2024. FCA has designated this recall with the number 66B, and it corresponds to the National Highway Traffic Safety Administration (NHTSA) campaign number 24V-436.

Stellantis RAM 2500 & 3500 Truck Problems

Posted on by

Transmission Fluid Leak May Cause Fire In Certain Stellantis Trucks

Chrysler’s parent company, Stellantis has issued a recall for certain 2020-2022 Ram 3500 and 2020-2023 Ram 2500 heavy-duty diesel trucks because of a problem that could result in an engine compartment fire. These trucks are equipped with Cummins 6.7L Turbo Diesel engines and 68RFE transmissions.

According to the defect report, a build-up of heat and pressure inside the transmission may result in transmission fluid being expelled from the dipstick tube. If the fluid comes in contact with an ignition source within the engine compartment, it could result in a vehicle fire. Stellantis is still working on a fix for this problem. Chrysler’s number for this recall is ZA3 and the NHTSA campaign number is 22V-835.

In the past two years, Stellantis’s Ram 2500 and Ram 3500 trucks have experienced a high number of recalls.

Owners Are Advised To Park Outdoors Due To Fire Hazard

It began in February 2021, when an investigation was opened into engine compartment fires in certain 2021-2022 Ram 2500, 3500 pickup trucks and 2021-2022 Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short within the solid-state intake heater grid relay could result in a fire, even when the ignition was turned off. Owners are advised to park these vehicles outside and away from structures and other vehicles until the problem has been fixed. Approximately 131,000 vehicles were affected by this recall.

Side curtain Air Bag May Not Deploy Properly

In November 2021 an airbag recall was issued for a small number of 2021-2022 RAM 1500, 2500 and 3500 trucks. The side air bag inflatable curtain (SABIC) assemblies in these vehicles were manufactured with a low gas mass that would result in an airbag non-deployment or slow deployment or a high gas mass that could result in aggressive airbag deployment and an increased risk of occupant injury in certain crash scenarios.

Stellantis RAM Electrical Problems

Stellantis issued three more recalls before their most recent for transmission fluid leaks that could cause fires. In March 2022, approximately 370, 000 Dodge Duango, RAM 2500, and Ram 3500 trucks were repaired for an electronic stability control (ECS) indicator light that could fail to illuminate during a control problem, increasing the risk of a crash.

In June 2022, certain 2022 Ram 1500, 2500 pickup trucks, and 3500 Cab Chassis vehicles with GVWR less than 10,000 lbs, experienced a radio software problem that could prevent the rear view image from displaying. These vehicles failed to comply with the Federal Motor Vehicle Safety Standards (FMVSS) for rear visibility.

In August 2022 a misaligned capacitor inside the ECM of certain 2022 Ram 2500, 3500, 4500 and 5500 trucks, could cause an electrical short, and a loss of drive power.

If your vehicle is experiencing repeated problems it could be a Lemon. Know your Lemon Law Rights. If you have any questions about your rights and the California Lemon Law, please call our office at 1-888-395-3666 and get some great Lemon Law advice!

Stellantis Safety Defects And Recalls

Posted on by

Stellantis is a global automaker and the owner of Chrysler, Dodge, Jeep, and RAM brands in the US. In the last year, they have issued numerous recalls affecting millions of vehicles. During this time, the company is also subject to ongoing investigations by the U.S. government automobile safety regulators.

Below is a summary of the Stellantis recalls in 2022.

Fuel Pump Failure (22V-767)
Models Affected: 2020-2022 Jeep Wrangler, Ram 1500, and 2021-2022 Jeep Gladiator vehicles equipped with 3.0L diesel engines.
A high-pressure fuel pump failure could introduce internally failed component debris into the fuel system potentially causing the engine to stall due to fuel starvation.

Front Seat Belt Pretensioner Could Fail (22V-766)
Models Affected: 2022 Ram 1500, Jeep Gladiator, and 2021 Jeep Wrangler vehicles.
An incorrectly welded micro gas generator (MGG) may lead to a pretensioner system failure that could fail to restrain an occupant during an accident.

Internal ECM Short May Cause Loss of Power (22V-642)
Models Affected: 2022 Ram 3500, 3500 Cab Chassis, Ram 2500, and 4500 and 5500 Cab Chassis vehicles equipped with Cummins 6.7L turbo diesel engines.
The engine control module (ECM) may have been built with a misaligned capacitor that can short-circuit, resulting in an internal loss of communication.

Rearview Camera Image May Not Display (22V-638)
Models Affected: 2020-2021 Jeep Wrangler, RAM 1500, and 2021 Jeep Gladiator
A software error could prevent the rear view image from displaying. These vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standards for rear visibility.

Tail Light Side Marker May Not Illuminate (22V-544)
Models Affected: 2022 Jeep Grand Cherokee and 2021-2022 Jeep Grand Cherokee L vehicles.
The tail light side marker assemblies may be damaged and not illuminated.

The Tire Pressure Monitoring System (TPMS) Sensor Battery May Fail Prematurely (22V-504)
Models Affected: 2022 Chrysler 300, 2022 Dodge Challenger, and 2022 Dodge Charger
According to the Federal Motor Vehicle Safety Standard (FMVSS) , all vehicles must be equipped with a tire pressure monitor system that detects”when one or more of a vehicle’s tires is significantly under-inflated and illuminates a low tire pressure warning telltale. The tire pressure system in the suspect vehicles may not detect low tire pressure. If the TPMS light illuminates because the battery in the sensor prematurely discharges, it could mask an actual low tire pressure condition, possibly resulting in tire failure.

Vehicle Rollaway Because Of ABS Malfunction (22V-426)
Models Affected: 2018-2019 Dodge Durango, and 2018-2019 Jeep Grand Cherokee
A malfunctioning antilock-brake system (ABS) module may illuminate the brake lights, and allow the vehicle to start and shift out of Park without the brake pedal being applied.

Rear view Image May Not Display (22V-407)
Models Affected: 2022 Ram 1500, 2500 pickup trucks, and 3500 Cab Chassis vehicles with GVWR less than 10,000 lbs
The radio software may prevent the rear view image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, “Rear Visibility.”

High-Pressure Fuel Pump Failure (22V-406)
Models Affected: 2014-2020 Jeep Grand Cherokee, and 2014-2019 RAM 1500
A high-pressure fuel pump (HPFP) failure may introduce internal debris into the fuel system, potentially resulting in fuel starvation.

Stuck EGR Valve May Cause Loss Of Power (22V-284)
Models Affected: 2021 Dodge Durango, Jeep Grand Cherokee WK, 2022 Jeep Grand Cherokee, and 2021-2022 Jeep Grand Cherokee L vehicles equipped with 3.6L engines.
The exhaust gas recirculation (EGR) valve may stick open, resulting in an unexpected loss of drive power.

Seat May Not Secure Properly (22V-181)
Models Affected: 2021-2022 Pacifica and 2021 Voyager
The second-row seat-to-floor mounting latch may bind and stick open, preventing the seat from properly securing to the floor.

Missing Weld From The Seat Back Frame To The Child Seat Tether Anchorage (22V-180)
Models Affected: 2021-2022 Jeep Grand Cherokee
These vehicles may have been built with a missing weld from the seat back frame to the child seat tether anchorage. These vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, “Child Restraint Anchorage Systems.”

Steering Assembly Bar Could Bind (22V-154)
Models Affected: 2021-2022 Dodge Durango and 2022 Jeep Grand Cherokee vehicles.
The steering gear rack bar may have been insufficiently hardened during manufacturing, possibly allowing it to bind within the steering rack. The problem could result in a loss of steering control.

ESC Light May Not Indicate Malfunction (22V-140)
Models Affected: 2021-2022 Dodge Durango, 2019-2022 RAM 2500, and 2019-2022 RAM 2500
An ABS control module software issue could prevent the electronic stability control (ESC) malfunction light from illuminating during certain conditions.