Category Archives: General Motors

News about General Motors automobile manufacturer. News about General Motors recalls, technical service bulletins (TSB), and problems regarding General Motors vehicles.

Cadillac, Chevy & GMC Seatbelt Safety Defect

Posted on by

General Motors has decided that a seat belt safety issue exists in certain 2020-2021 Cadillac, Chevrolet and GMC vehicles. They will be contacting owners with instructions to return to their dealerships for repairs.

According to the safety report filed with the NHTSA, the wrong seat belt bolt may have been used at one or multiple locations to secure the seat belt to the vehicle. If an incorrect bolt was used, the seat belt may not be properly attached and may not properly restrain an occupant during a crash.

Vehicles Affected Include
2020 Chevrolet Bolt EV
2021 Cadillac Escalade
2021 Cadillac Escalade ESV
2021 Chevrolet Blazer
2021 Chevrolet Camaro
2021 Chevrolet Colorado
2021 Chevrolet Equinox
2021 Chevrolet Silverado 1500
2021 Chevrolet Silverado 2500
2021 Chevrolet Silverado 3500
2021 Chevrolet Suburban
2021 Chevrolet Tahoe
2021 GMC Canyon
2021 GMC Sierra 1500
2021 GMC Sierra 2500
2021 GMC Sierra 3500
2021 GMC Yukon
2021 GMC Yukon XL

Dealers will correct the problem by replacing any suspect bolts. GM’s number for this recall is N202322230 and the NHTSA campaign number is 20V-811.

2020 Chevrolet Bolt EV Reduced Braking

Posted on by

A small number of 2020 Chevrolet Bolt EV owners will be returning to their dealerships to repair a problem affecting the brakes in their vehicles. General Motors has decided that this defect can affect vehicle safety.

According to the defect report, certain 2020 Chevy Bolt EVs may have improperly cast front left brake calipers. (Iron used to manufacture the caliper was not properly treated by the supplier prior to casting.) During a high pressure braking event, the caliper could fracture and brake fluid would be lost to half of the vehicle’s braking system. The problem could result in an unexpected reduction in brake performance and an increased chance of an accident.

Owners receiving notices will be asked to return to their dealerships to have the casting lot number of the front left brake caliper inspected and replace as necessary. GM’s number for this recall is N202321400 and the NHTSA campaign number is 20V-808.

Chevrolet And GMC Trucks – Center Seating/Console Rattle

Posted on by

A defect relating to seatbelt safety will have approximately 624,000 Chevrolet and GMC truck owners returning to their dealerships for an inspection and repairs. These vehicles are equipped with a center front row seating position.

According to the NHTSA defect report, the center front row seatbelt bracket may not be properly secured to the seat frame. If the bracket is loose, the seatbelt will not restrain the occupant during a crash or high-speed braking event.

WARNING: Signs that the problem exists include a rattling coming from the center seat / console area, the center front seat belt will feel loose or could detach from the seat completely.
Vehicles Affected Include
2019-2021 Chevrolet Silverado 1500
2020-2021 Chevrolet Silverado 2500
2020-2021 Chevrolet Silverado 3500
2021 Chevrolet Suburban
2021 Chevrolet Tahoe
2019-2021 GMC Sierra 1500
2020- 2021 GMC Sierra 2500
2020- 2021 GMC Sierra 3500
2021 GMC Yukon XL

Dealers will inspect the left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary. GM’s number for this recall is N202314670 and the NHTSA campaign number is 20V-792.

2021 Cadillac Escalade Dim Seatbelt And Airbag Warning Lights

Posted on by

Some 2021 Cadillac Escalade and Escalade ESV vehicles may fail to comply to the Federal Motor Vehicle Safety Standards (FMVSS) for controls and displays of the occupant crash protection system.

According to the defect report, the front passenger seat belt and airbag status lights on the overhead console could be unknowingly set to night mode, making them not visible to vehicle occupants.  The body control module (BCM) software in these vehicles may inadvertently set the “night mode” in the daytime when the remote start is used or when the vehicle is turned off and re-started without opening the door for ten minutes.  If night mode is active during the daytime the driver and front passenger may not notice the warning that the seat belt is unbuckled or that the airbag is deactivated.  This problem can increase the risk of injury during a crash.

General Motors will be notifying owners of affected vehicles beginning in February.  Dealers will correct the problem by updating the BCM software.  GM’s number for this recall is N202319980 and the NHTSA campaign number is 20V-790.

GM, Nissan and VW Recalled For Defective Tires

Posted on by

The owners of certain 2020-2021 General Motors, Nissan and Volkswagen vehicles will be contacted by the automobile manufacturer regarding a problem that could exist with their tires. Continental Tires of America (CTA) have initiated a recall for tires that may have been installed as original equipment on some models.

General Motors Vehicles Affected
2020 Buick Enclave
2020 Cadillac XT5
2020-2021 Chevrolet Silverado 1500
2020 Chevrolet Traverse
2020 GMC Acadia
2020-2021 GMC Sierra 1500
Nissan Vehicles Affected
2020 Nissan Altima
Volkswagen Vehicles Affected
2021 Volkswagen Atlas
2020-2021 Volkswagen Atlas Cross Sport

According to CTA, over-cured tires could experience a break in the sidewall with sudden air loss or could develop a belt edge separation that could lead to partial or full tread/belt loss. These conditions could increase the risk of an accident.

Chevrolet Bolt EV Battery Problem

Posted on by

An investigation into battery fires in certain 2017-2019 Chevrolet Bolt EVs has resulted in a recall involving approximately 50,000 vehicles.

According to the defect report, if the batteries in certain vehicles within this population are charged to full capacity or close to full capacity, they could be at risk of overheating and catching fire. GM is still investigating the cause of the problem and will notifying owners of an interim repair where the hybrid propulsion control module will limit the battery to a 90% charge. A final remedy is still under development.

Owners are advised to activate either the Hill Top Reserve (2017 and 2018 models) or Target Charge Level (2019 models) feature in their vehicle to limit the charge level to 90%, or park outside, until the software update is completed.

GM’s number for this recall is N202311730 and the NHTSA campaign number is 20V-701.

Weak Driveshaft Welds – Chevy Silverado and GMC Sierra Trucks

Posted on by

General Motors will be contacting a small number of 2019-2020 Chevrolet Silverado 1500, 2020 Chevrolet Silverado 2500 and 2019-2020 GMC Sierra 1500 owners. because of a manufacturing problem affecting the power train in their vehicles.

According to the defect report, these trucks may contain a drive shaft with an improperly welded yoke to tube joint. This defective weld could case the drive shaft to separate under load, causing a loss of propulsion and an increased risk of an accident.

GM will be asking owners to return to their dealers to have the driveshaft replaced. GM’s number for this recall is N202314870 and the NHTSA campaign number is 20V-650.

Engine Stall From Insufficient Fuel Supply

Posted on by

General Motors will be asking the owners of certain 2020 GM automobiles to return to their dealerships to fix a problem affecting the fuel supply system in their vehicles. The vehicles affected include 2020 Buick Enclave, Cadillac XT5, Cadillac XT6, Chevrolet Traverse and GMC Acadia.

According to the defect report, the fuel pump assemblies in these vehicles may have been produced with burrs inside the mixing tube. Over time, these burrs could prevent the transfer of fuel from the secondary side of the fuel tank to the primary side. At low fuel levels, the engine may not receive enough fuel and the engine could stall unexpectedly. A stall without warning, especially at high speeds, could increase the risk of an accident.

Dealers will correct the problem by replacing the fuel pump module. GM’s number for this recall is N202314760 and the NHTSA campaign number is 20V-639.